The first - commonly referred to paragraph firing arsenic removal section. Here, the temperature is controlled at 925 O F and the oxygen supply is controlled to the lowest value. In order to ensure the removal of arsenic in the form of trivalent god, it is usually kept in the reduced state at the beginning of the calcination, because the presence of excess oxygen promotes the oxidation of the third-order arsenic to pentavalent arsenic, which is arsenic of ferric iron . salt form surface film left on the calcine to delay or obstruct feed of arsenic - volatilization step, and the influence of the calcine leaching of gold.
The second crucible is called oxidative roasting. The fluidized bed material into the calcined under oxidizing conditions activity - oxidation step, and the feed sulfur - removing step, however, this is impossible to achieve do not want to happen firing die, because complete removal of the sulfur, iron is bound to promote the continued Oxidized into magnetite and left in the micropores of the calcine, thereby preventing the permeation of the cyanide solution.
Table 1 Â Standard analysis results of factory processing
name    Weigh | Tons / day | Au (oz / ton) | Fe | S | As | Sb |
Grinder feeding | 1250 | 0.19 | 6.60 | 2.2 | 0.85 | 0.04 |
Flotation concentrate | 130 | 1.60 | 23.00 | 17.5 | 7.6 | 0.18 |
Calcination | 100 | 2.00 | 27.80 | 2.5 | 1.0 | 0.13 |
Electrostatic dust collector dust | twenty two | 1.43 | 18.00 | 2.75 | 2.29 | 0.30 |
Bag dust collector dust | 15 | 0.12 | 1.75 | 0.50 | 70.00 | 0.50 |
A brief history of gas purification operations
Jat mine gas purification was originally built in October 1951 - the seat low temperature Curt McConnell type electrostatic precipitators for dust collector calcine and condensate from gas exports Edward roaster down arsenic trioxide. In early 1952 installed the first - stage fluidized roaster - seat diameter
It appears that in terms of gold extraction, the first - stage fluidized roaster is strictly controlled air to maintain operation under a moderate reducing atmosphere, so that the furnace outlet gas contains a high concentration of sulfur dioxide (substantially not trioxide). sulfur). When the temperature of the electrostatic precipitator is still gas at SO 2 and SO 3 is close to the condensation temperature, the surface of the non-conductive arsenic dust particles adsorbs SO 3 , which causes the suspended dust to become electrically conductive and be recovered. The amount of SO 3 in the outlet gas of the roaster is not high, so that the non-conductive dust particles of the condensed arsenic are discharged from the chimney through the electric precipitator.
In 1955 , a second Cotnel-type high-temperature electrostatic precipitator was built. It was used to selectively recover the impurities contained in the roasting dust before the arsenic condensed in the original low-temperature electrostatic precipitator was collected. gold. The two (hot and cold) electrostatic precipitators operate in tandem to increase the efficiency of the dust collection, but the condensed arsenic particles are not sufficiently conductive for recycling in low temperature electrostatic precipitators. Attempts to increase the amount of sulfur trioxide in the exit gas of the roaster have not been successful. Finally , the mixed recovery of As 2 O 3 and the baking dust is reduced to 60% , which makes it necessary to operate the two electrostatic precipitators at low temperatures.
1957 - Taiwan small bag filter it - part of the roaster gas were tested. The results show that the arsenic capture efficiency of this device is as high as 99% , and the service life of the bag is satisfactory.
1958 is installed - the expansion of the two fluidized solids roaster seat. At the same time - a standard 30- Draco bag filter with 8 compartments was put into operation. It was used to capture the roasting dust in the furnace gas and the condensed dioxide. After the good in this new fluidized solids roaster operation, this type of electrostatic precipitator on the Côte Nair as - as to promote the flow of flue gas station high temperature electrostatic precipitator. From this, selective collection of gold-containing roasting dust and condensed arsenic trioxide is put into practice. In the spring of 1962 , the original low-temperature Cotnel electrostatic precipitator was modified, and it is currently operating in parallel with a high-temperature electrostatic precipitator.
Have you seen all the inflatable toys that people launch around Christmas every year? Christmas inflatable toys are one of the most popular and beautiful ways. You can use them to decorate your lawn to show your Christmas spirit.
There are so many different options to choose from, which may make it a bit difficult for you to choose which options for your lawn during Christmas.
If you want the exterior of your home to look good, you need to consider a few different factors before you decide which inflatable product is best for your party.
You need to decide what to display on the inflatable toys outside your home. You may want to choose between a religious display and a Santa Claus display, these are the two most popular inflatable decorations you will find.
You can also find things like inflatable snowmen and wreaths in different places in the yard, they look great.
In addition, you need to make sure to find a good place to buy the decorations you decide. You can find inflatable Christmas decorations in department stores, but you may find the best prices through online shopping.
Speaking of Christmas, I am happy to find the bargains you want, such as inflatable Christmas garden decorations. In just a few minutes of online research, you can usually find very big savings.
Inflatables Christmas Tree,Christmas tree Christmas Inflatables,Christmas Tree Wreath Inflatables,Giant Inflatable Christmas Tree
Zhoushan Fule Christmas Decorations Co., Ltd. , https://www.fuleinflatable.com